| Topic Starter |
Message |
 5 RRs and I have to give up |
Pawl
 20th Nov 2024 10:17pm
|
Forum: My Range Rover · Replies: 75 · Views: 4704 · Subject: 5 RRs and I have to give up |
| A good 'result' - but bizarre 🤣 |
| 5 RRs and I have to give up |
Pawl
18th Nov 2024 10:40pm
|
Forum: My Range Rover · Replies: 75 · Views: 4704 · Subject: 5 RRs and I have to give up |
| I think the "error" might be because the BCM outputs a PWM (Pulse Width Modulation) signal - effectively pulses of voltage to drive the Servotronic valve. The gaps between the pulses reduces ... |
| 5 RRs and I have to give up |
Pawl
15th Nov 2024 2:06pm
|
Forum: My Range Rover · Replies: 75 · Views: 4704 · Subject: 5 RRs and I have to give up |
I agree with GraemeS, you've eliminated the Servotronic valve.
The only extra test I did was to apply a direct 12V to it to bypass the BCM effects and confirm that it gave permanent full assistance - ... |
| 5 RRs and I have to give up |
Pawl
14th Nov 2024 10:37am
|
Forum: My Range Rover · Replies: 75 · Views: 4704 · Subject: 5 RRs and I have to give up |
I would expect any restriction in pipework etc to only cause a flow problem as any fluid getting through will allow full pressure to be generated, but might take longer.
So a restriction might cause ... |
| 5 RRs and I have to give up |
Pawl
11th Nov 2024 10:06pm
|
Forum: My Range Rover · Replies: 75 · Views: 4704 · Subject: 5 RRs and I have to give up |
I ended up creating a pressure test kit for my PAS when it was playing up & was consistently heavier than tolerable & i'd eliminated the Servotronic & BCU.
The gauge showed I was only ach ... |
| Is This my EGR Intake Pipe Gone? |
Pawl
26th Oct 2024 9:20pm
|
Forum: Technical (L322) · Replies: 2 · Views: 227 · Subject: Is This my EGR Intake Pipe Gone? |
Jon,
I think your diagnosis is correct. I've responded to your PM.
It appears to be the same failure I had.
I'm guessing the EGR pip manufacture quality control wasn't very good on the early TDv8 ... |
| [Wanted] Battery for L322 |
Pawl
26th Oct 2024 8:10am
|
Forum: For Sale & Wanted · Replies: 5 · Views: 471 · Subject: [Wanted] Battery for L322 |
An 015 size is on the small size gor an L322.
Best is an 020 - but doesn't fit all.
Or slightly shorter is the recommended size which is the 019 |
| adjusting the track |
Pawl
25th Oct 2024 8:36am
|
Forum: Technical (L322) · Replies: 6 · Views: 680 · Subject: adjusting the track |
You have a few options :
Try applying heat to the area and see if that might loosen the hold
Try repeating application of wd40 or similar - over a few days.
Worst case is remove the rod end at t ... |
| 3.6 TDV8 EGR pipe not lining up |
Pawl
2nd Sep 2024 5:17pm
|
Forum: Technical (L322) · Replies: 6 · Views: 405 · Subject: 3.6 TDV8 EGR pipe not lining up |
Tomo,
from my limited experience a couple of years ago, Bell Auto Services are not happy to provide modified ECU maps if the engine has fault codes that are current.
If you didn't know, their modif ... |
| Brake pedal sinks to floor |
Pawl
15th Aug 2024 1:38pm
|
Forum: Technical (L322) · Replies: 38 · Views: 2479 · Subject: Brake pedal sinks to floor |
Hi All, Bit of an update!
I managed to remove the master cylinder today (at last!). 
........
Plugged in the laptop and ran through the bleeding process in SDD. Now the brakes feel like t ... |
| Brake pedal sinks to floor |
Pawl
9th Aug 2024 10:25pm
|
Forum: Technical (L322) · Replies: 38 · Views: 2479 · Subject: Brake pedal sinks to floor |
Based on when it happens, I agree with you, it's very likely to be the mastercylinder.
Have you found a supplier for the internal seals to replace them or will you take it apart to "just" c ... |
| Brake pedal sinks to floor |
Pawl
9th Aug 2024 6:32pm
|
Forum: Technical (L322) · Replies: 38 · Views: 2479 · Subject: Brake pedal sinks to floor |
Can you clarify when you get your sinking pedal ?
Is only immediately after starting the engine ?
Or anytime after the engine is started ?
If you're holding the pedal down while the engine is st ... |
| Power steering problem. |
Pawl
29th Jul 2024 8:51am
|
Forum: Maintenance & Mods (L322) · Replies: 5 · Views: 479 · Subject: Power steering problem. |
If the problem always gets better when you increase engine speed its most likely to be a problem with the PAS pump.
The Pump can be checked for output by having the car in neutral with engine runnin ... |
| Gear box behavior. |
Pawl
22nd Jul 2024 12:09pm
|
Forum: Technical (L322) · Replies: 3 · Views: 413 · Subject: Gear box behavior. |
Are you sure its a "5" or could it be "S" ?
My 2007MY car only ever indicates "S" on selecting Sport mode, then indicates the actual gear if the gear selector is used ... |
| 3.6TDV8 Power Steering Pump Replacement |
Pawl
18th Jul 2024 10:49pm
|
Forum: Maintenance & Mods (L322) · Replies: 21 · Views: 9184 · Subject: 3.6TDV8 Power Steering Pump Replacement |
Mine is normally quiet under all conditions except full lock - unless fluid level is low and presumably it's then pulling air through.
Update : The whining is a useful "prompt' to top up the fl ... |
| |
