Hi, just had my 05/06 rr 4,2 sc in for its service at a local independent, i asked them to investigate a slight wobble on the steering post 50mph, they said it was wear on the steering rack, and a new one was £1800, i have looked one bay for recon units, is this a big job or a straightforward swap ? thanks,Jamie jamie

Check the connection of the steering column lower universal joint to the splined connection on the rack is tightened up properly first , as this is a common reason for steering wheel play.

On the steering rack replacement, if done 'by the book' it is a pretty time consuming job, requires the engine mounts disconnected and the engine lifted to give the room to get the rack out.

However, a good indy (or good main dealer) can remove the old rack and fit the replacement without the hassle by taking the tie ends of the rack, jiggling out the old rack and fitting the replacement rack in sections.

If you get a second hand rack of the fleabay, it can be a good idea to fit new cooler pipes, tie rod ends, track rod ends, tie rod end boots and servotronic valve prior to fitting. These bits are relatively cheap and will avoid any problems with the second hand rack.

You should be able to get a rack off the fleabay for around £200, so a massive saving on the £1800 cost of a remanufactured unit from the dealers.

Last edited by Discotigger on 15th Nov 2014 8:35pm. Edited 1 time in total

My gut intinct would be to get a 2nd opinion before you go further.

.. Howard
____________________________________________________
2002 4.4 V8 LPG Tartarini
Have RSW AllComms in Cheshire J17 M6 - happy to help.
*Gone: Classic Vogue SE Auto V8 3.9

steering wobble at 50mph is normally tyres need balancing... ... - .- -.




Y. O. L. O.
.

Certainly worth exhausting every other avenue first sir

Never heard a rack give those symptoms, if the rack is worn it will have play in it, that you can feel at rest.

As the rest say.... get a 2nd opinion and get all the suspension arms and bushes checked... Pete
__________________________________________________
2014 L405 Autobiography SDV8 4.4 Loire Blue Ebony interior
2011 L322 Vogue SE 4.4 TDV8 Baltic Blue. Sold
2012 L322 Autobiography 5.0 Supercharged Ipanema Sand Sold
2002 L322 Vogue 4.4 V8 Epson Green (Fatty Offroader) Sold
-Click for Project Fatty off roader-

Would be supprised if it was the rack internals, more likely inner tie rods or one of the suspension bushes, racks aren't cheap but are available second hand, though I would have thought you may be buying as many problems as you have now.

As has been said, check all other possibilities first, before plunging in as you will be really hacked off if it's not the rack when all said and done! There is nothing that can't be fixed with a hammer😜😜
FFRR 4.4 SDV8 Autobiography Santorini Black.
KIA E-Niro 4+
2021 Discovery 5 D300 MHEV commercial

thanks guys, I've had the wheels balanced, it is a bit better, i will see how she goes for the next 500 miles or so, and maybe its time to find another specialist ? thanks again .J jamie

Were all four wheels balanced or just the front two? If the rears were balanced too then swap the fronts & rears around and see if that helps

do you have standard LR wheels or maybe 22'' aftermarket ones, they could be the reason for the wobble... ... - .- -.




Y. O. L. O.
.

just running the standard 20' wheels, she has 135k on her but until this has been as tight as a drum, time will tell i guess ? jamie

I meant to say in my earlier post that I had a similar problem when I bought the car.

I got 4 new tyres ... some old ones were ok but with winter on way I changed them all ... and the problem was solved.

.. Howard
____________________________________________________
2002 4.4 V8 LPG Tartarini
Have RSW AllComms in Cheshire J17 M6 - happy to help.
*Gone: Classic Vogue SE Auto V8 3.9

@ gpzjamie, I had this problem at a client´s Range Rover 2005, and after fitting one of this parts, the problem was solved...., best rgs, Uli

http://www.ebay.de/itm/ABS-SPURSTANGENKOPF...19f6b39b97 L405 SDV8 2017 + Lancia Flavia Coupe 1964 + RRS L494 3.0 SDV6 + C220CDI Convertible 2021

With all due respect to the garage... If it was as simple as a track rod end! Then I'm sure that would have been diagnosed in a heartbeat Meerbusch...

The question the OP is asking is, "do steering racks fail often?" and you are quite right sir, the balljoints do fail on a regular basis... But to miss a balljoint & diagnose a replacement rack would be inexcusable...

Hence advice above, to exhaust all other options first

Does not seem like it is the rack, however, get in touch with kellybraysteering

I ordered mine from them and they offered a fantastic customer service + refurbed rack

email : <kellybraysteering>; l=Oo\________/oO=l l:OolΞΞΞΞΞΞΞloO:l

Current
RANGE ROVER Vogue 4.4L SDV8 - 2013 - Indus Silver, on Almond.
RANGE ROVER Vogue 4.4L V8 - 2002 - ex-2003 G4 Challenge Event Vehicle, Stage 3: Australia
RANGE ROVER HSE 4.4L V8 - 2004 - one-of-one Overfinch
RANGE ROVER P38a 4.0L V8 - 1999 - ex-2000 TReK Event Vehicle: South Africa

Previous:
RANGE ROVER Vogue 4.4L TDV8 - 2012 - RANGE ROVER 3.6L TDV8 x3 - RANGE ROVER Td6 x1 - RANGE ROVER Classic 3.5L V8 x1