Desperate need of help with this one!!

OSR all stripped just need to remove drive shaft from drive flange to check the ABS ring on the drive shaft after an ABS fault code for that corner came up.

So far the lump hammer and the useless tool below have failed.

Does anyone know of tool out there that can do this? I have seen posts where people make tools, unfortunately I don’t have access to welding or matching facilities. I need to buy a tool.

Any ideas?

Check out Sykes Pickavant website, not cheap, but they sell some seriously good stuff.
Mike. G reg 2.5VM Vogue Portofino red 1991- 1999
V reg 2.5td P38 Rioja red 1999- 2006
53 reg td6 Vogue Oslo blue 2006- 2015
11 reg 4.4 TdV8 Vogue SE. Baltic blue 2015- date.
https://www.fullfatrr.com/forum/topic56162...tty+affair

I’ve used a hydraulic one before for a stuck driveshaft. That pictured on will likely not be large enough and wil snap under high load.

I had to use a blow torch on the hub, and a pry bar to tighten down on the ram. I burst the seals but for a one off effort it worked. V8 or else ...

Have you got (or can you borrow) a big hammer drill - the bigger the better?
I’ve found them quite effective in hammer only mode obviously

Update on this. In the end due to not wanting to damage the driveshaft with the lump hammer I have pulled the shaft complete knuckle/ hub out. Going to take the assembly to my local garage to press the shaft out.

However! The aluminium EPB cable is solidly rusted into the knuckle and of course snapped.

Seriously considering dropping the rear subframe to do this job properly. Shot blast and powder coat subframe, new bushes throughout, new hand brake cables, new brake lines - the full shabang. And of course treat any corrosion underneath.

Looks like the full 4.4 TDV8 exhaust has to come off.

Anyone else gone this far with back end refurbishment? Kevin
2012 L322 Westminster 4.4 TDV8
1999 P38A 4.0 SE - Sold

David did it with his early S/C... very similar to yours...

https://www.fullfatrr.com/forum/topic57991.html Pete
I now have permission from the boss to use Y.O.L.O. Enjoy life
__________________________________________________
2014 L405 Autobiography SDV8 4.4 Loire Blue Ebony interior
2011 L322 Vogue SE 4.4 TDV8 Baltic Blue. Sold
2012 L322 Autobiography 5.0 Supercharged Ipanema Sand Sold
2002 L322 Vogue 4.4 V8 Epson Green (Fatty Offroader) Sold
-Click for Project Fatty off roader-

Hi Pete,

Thanks for link, very helpful👍👍 Kevin
2012 L322 Westminster 4.4 TDV8
1999 P38A 4.0 SE - Sold

try Roger Hutchings on Facebook (https://www.facebook.com/roger.hutchings.79) he makes a tool for removing the drive shaft that has been very successful.

Click image to enlarge