hi folks on leaving my sidelights on all day and night and a call out from aa finally got some power to battery and got her open started no probs battery ok however on trying to open drivers door which would not open with key i snapped cable for outside door handle so card off door to find problem ok needs new cable when wiring speakers etc back i have 2 spare wires 2 into one blue small connector pin hole connections pretty much same as small speaker connections ok so searched everywhere for somewhere to connect to without any joy put card back on everything working ok exept air suspension has stopped working no lights can anybody shed some light as to where these wires go as they must be cause of failure suspension was working fine after battery charged any help would be much appreciated richard

hmm
sure you haven't plugged the wrong cable into the door access mode connector on the driver switch pack?
I seem to recall a post that its possible to transpose the wiring to a couple of the connectors on the switchpack , one of them being the access height control connector

thanks for the reply all wires that were connected to switch module were not disconnected both speakers are working normally .can not for the life of me see another connection. i must be missing something there are 3 connectors with multi wires going to switch. box these wires were left in situ. speaker wires were disconnected and i must have pulled these mystery wires out but from where i just can not see i have ordered new cable for door opener and will wait till it comes before taking apart again any ideas would be great richard

Air bag?

Something you have not got but is included with the loom?

i do have air bag and it is still connected. these wires come from loom in the door and look like they should go to card somewhere very similar to speaker wire connection

What colours are the wires? John
2008 Stornoway Grey 3.6 Tdv8 Vogue
2005 TD6 Java Black Vogue - Written off!!
GAP iiD BT
2003 Discovery TD5 Auto, Nanocom Evolution - gone to a new home!
MasseyFerguson 152 - No electronics!! - Sold

i think brown and blue but i would have to take card off to check i stupidly did not take pics of it when i put it back together but they are dark colours

The wires aren't for the puddle lights in the bottom of the door card or the door handle leds by any chance?
With regard to the air suspension not working I would be inclined to take the door card off again and one by one un-plug all the door connectors and then re-connect and see what happens.

Don't how how far this will take you but behind the driver's door panel the wire colours are:
Ride Height Switch - SR/N/YG
Puddle Lamp - N/RU
Mid range Speaker - SN/SB
High Range Speaker -YB/YR
Airbag -Y/N
Anti Trap Sensor -N/NR
Window Motor -BG/BS

S = Grey
N = Brown
Y = Yellow
G = Green
R = Red
B = Black
U = Blue


There is other wiring but something to be going on with.  John
2008 Stornoway Grey 3.6 Tdv8 Vogue
2005 TD6 Java Black Vogue - Written off!!
GAP iiD BT
2003 Discovery TD5 Auto, Nanocom Evolution - gone to a new home!
MasseyFerguson 152 - No electronics!! - Sold

Last edited by Weegie on 20th Jul 2016 2:21pm. Edited 1 time in total

thanks for that will take door card off when new door able arrives everything is working including puddle light windows central locking speakers its just the air suspension no lights on hight selector switch at all

I'm pretty sure that as you have no lights at all on the air suspension switch panel a hard fault has been logged on the ECU for whatever reason which will require to be cleared by connection to a diagnostics unit.

ok do you think i have done something inside door to cause this?

I'm afraid I simply don't know.
As far as I'm aware the only thing in the doors that could possibly cause a problem with the air suspension are the Hall sensors in the door locks that indicate when the doors are open and closed. It's common for the air suspension to be inhibited when a door is open but usually the indicator lights stay on on the switch panel.
I assume you have checked the fuse for the air suspension? Fuse 57, 15A on the front fuseboard behind the glove box.

will check fuses tomm .would have done but can not see any reason they would have blown

hi folks all is well again fuse was ok .took panel off and on with new door cable. working fine odd wires go nowhere .had to do reset at local garage air susp fine a lesson to be learned not to leave ones light on all night .going to have a cable fitted from battery to caravan socket wont get caught like that again. thank you for all the replies richard